Introduction 4Instrument Cluster 12Warning lights and chimes 12Gauges 18Message center 20Entertainment Systems 37How to get going 37AM/FM stereo with
These are some of the symbols you may see on your vehicle.Vehicle Symbol GlossarySafety AlertSee Owner’s GuideFasten Safety Belt Airbag - FrontAirbag
To install, follow the removal procedures in reverse order.Exterior tiedown hooksExterior tiedown hooks mounted onthe side of the pickup box:• can be
Activating Cargo Cage TheftDeterrent Device:The following procedure can bedone with the cargo cage in thestowed or extended position.1. Locate the Phi
To open the front panel:• Open the driver side lock coverand unlock the front panel usingyour ignition key.• Lift the panel to access items inthe pick
Failure to secure the rear panel could damage the tonneau coveror vehicle.To remove the tonneau cover:The tonneau cover weighs 70 lb.(29 kg) and needs
WARNING: Do not leave children, unreliable adults, or animalsunattended in the vehicle. On hot days, the temperature in thepickup box can rise very qu
Pickup box storage compartmentThe storage compartments are located inside the pickup box behind thewheel wells.The storage compartments havebeen desig
To adjust cross-bar position (ifequipped):1. Loosen the thumbwheel at bothends of the cross-bar (If thethumbwheel is too tight to releaseby hand, a sm
KEYSOne key operates the door, tailgate, and tonneau cover locks and startsthe vehicle. Always carry a spare key with you in case of an emergency.Your
Deactivating/activating autolockYour vehicle comes with the autolock feature enabled. There are fourmethods to enable/disable this feature:• Through y
Keyless entry keypad procedure1. Turn the ignition to the off position.2. Close all doors.3. Enter 5–digit entry code4. Press and hold the 3 • 4. Whil
Vehicle Symbol GlossaryPower WindowsFront/RearPower Window LockoutChild Safety DoorLock/UnlockInterior LuggageCompartment ReleasePanic Alarm Engine Oi
Power door unlock/lock procedureYou must complete Steps 1-5 within 30 seconds or the procedure willhave to be repeated. If the procedure needs to be r
Power door lock/unlock inhibit feature (if equipped)If the key is not in the ignition, all doors are closed, and the vehicle hasbeen locked using the
CHILDPROOF DOOR LOCKS• When these locks are set, therear doors cannot be opened fromthe inside.• The rear doors can be openedfrom the outside when the
Your vehicle is equipped with a remote entry system which allows you to:• unlock the vehicle doors withouta key.• lock all the vehicle doors withouta
Locking the doors1. Press and release to lock all the doors. The lamps will flash.Note: If any door is not closed properly, the lamps will not flash u
2. Do not wipe off any grease on thebattery terminals on the backsurface of the circuit board.3. Remove the old battery.Note: Please refer to localreg
3. Turn the key from the 1 (off)position to 3 (on).4. Cycle eight times rapidly (within10 seconds) between the 1 (off)position and 3 (on). Note: Theei
SECURICODE™ KEYLESS ENTRY SYSTEM (IF EQUIPPED)You can use the keyless entrykeypad to:• lock or unlock the doors withoutusing a key.• activate or deact
Erasing personal code1. Enter the factory set 5–digit code.2. Within five seconds, press the 1 • 2 on the keypad and release.3. Press and hold the 1 •
Note: Large metallic objects, electronic devices that are used topurchase gasoline or similar items, or a second coded key on the samekey chain may ca
WARNING LIGHTS AND CHIMESStandard instrument clusterOptional instrument clusterWarning lights and gauges can alert you to a vehicle condition that may
Replacement keysIf your keys are lost or stolen and you don’t have an extra coded key,you will need to have your vehicle towed to an authorized dealer
6. Turn the ignition to the 1 (off) position and remove the secondpreviously programmed coded key from the ignition.7. After three seconds but within
SEATINGWARNING: Reclining the seatback can cause an occupant toslide under the seat’s safety belt, resulting in severe personalinjuries in the event o
To adjust the head restraint, do the following:1. Adjust the seatback to an upright driving/riding position.2. Raise the head restraint bypulling up o
To remove the adjustable head restraint, do the following:1. Pull up the head restraint until itreaches the highest adjustmentposition.2. Simultaneous
WARNING: To minimize the risk of neck injury in the event of acrash, head restraints must be installed properly.Adjusting the front manual seat (if eq
Using the manual lumbar support (if equipped)For more lumbar support, turn thelumbar support control toward thefront of vehicle.For less lumbar suppor
WARNING: To reduce the risk of possible serious injury: Do nothang objects off seat back or stow objects in the seatback mappocket (if equipped) when
Press the control to recline theseatback forward or rearward.Using the power lumbar support (if equipped)The power lumbar control is located on the ou
The heated seat control is located in the lower center of the instrumentpanel.To operate the heated seats:• Push control to activate.• Push again to d
Service engine soon: The serviceengine soon indicator lightilluminates when the ignition is firstturned to the on position to checkthe bulb and to ind
Refer to Safety seats for children later in this chapter.WARNING: If the head restraint has been removed from aseating position to accommodate a high
To return the seat to the upright position:1. Pull up on the handle, and rotatethe seatback until you hear a click,locking it in the upright position.
SAFETY RESTRAINTSPersonal Safety System姞The Personal Safety System威 provides an improved overall level offrontal crash protection to front seat occupa
Driver and passenger dual-stage airbag supplemental restraintsThe dual-stage airbags offer the capability to tailor the level of airbaginflation energ
The front passenger sensing system can automatically turn off the frontpassenger airbag and passenger seat-mounted side airbag. The system isdesigned
addition, the RCM also monitors the restraints warning light in theinstrument cluster. A difficulty with the system is indicated by one ormore of the
WARNING: Each seating position in your vehicle has a specificsafety belt assembly which is made up of one buckle and onetongue that are designed to be
• Front and rear seats2. To unfasten, push the release button and remove the tongue from thebuckle.• Front and rear seatsAll safety restraints in the
Automatic locking modeWhen to use the automatic locking modeIn this mode, the shoulder belt is automatically pre-locked. The belt willstill retract to
WARNING: After any vehicle collision, the combination lap andshoulder belt system at all passenger seating positions must bechecked by an authorized d
Brake system warning light: Toconfirm the brake system warninglight is functional, it willmomentarily illuminate when theignition is turned to the on
Front safety belt height adjustmentYour vehicle has safety belt heightadjustments at the front outboardseating positions. Adjust the heightof the shou
To adjust the comfort guide:1. Slip the shoulder belt into thebelt guide.2. Slide the guide up or down alongthe webbing so that the belt iscentered on
Conditions of operationIf... Then...The driver’s safety belt is notbuckled before the ignitionswitch is turned to the onposition...The safety belt war
The Belt-Minder威 feature uses two different warning chimes. During thefirst minute of activation, the warning chime will sound once everysecond. The r
The following are reasons most often given for not wearing safety belts(All statistics based on U.S. data):Reasons given... Consider...“Crashes are ra
Reasons given... Consider...“I have an airbag” Airbags offer greater protection whenused with safety belts. Frontal airbagsare not designed to inflate
The driver and front passenger Belt-Minder威 features can bedeactivated/activated by performing the following procedure:Before following the procedure,
AIRBAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS)Important SRS precautionsThe SRS is designed to work withthe safety belt to help protect thedriver and right
WARNING: Never place your arm over the airbag module as adeploying airbag can result in serious arm fractures or otherinjuries.To properly position yo
Children and airbagsChildren must always be properlyrestrained. Accident statisticssuggest that children are safer whenproperly restrained in the rear
Charging system: Illuminates when the battery is not charging properly.If it stays on while the engine is running, there may be a malfunctionwith the
The airbags inflate and deflaterapidly upon activation. After airbagdeployment, it is normal to notice asmoke-like, powdery residue orsmell the burnt
• one or more impact and safing sensors.• a readiness light and tone.• diagnostic module.• and the electrical wiring which connects the components.• F
The front passenger sensing systemuses a ⬙passenger airbag off⬙ or⬙pass airbag off⬙ indicator which willilluminate and stay lit to remind youthat the
OccupantPass Airbag OffIndicator LampPassenger AirbagEmpty seat Unlit DisabledSmall child in childsafety seat or boosterLit DisabledSmall child with s
ObjectsPass Airbag OffIndicator LampPassenger AirbagSmall (i.e. three-ringbinder, small purse,bottled water)Unlit DisabledMedium (i.e. heavybriefcase,
In case there is a problem with thefront passenger sensing system, theairbag readiness lamp in theinstrument cluster will stay lit.If the airbag readi
A difficulty with the system is indicated by one or more of the following:• The readiness light will eitherflash or stay lit.• The readiness light wil
How does the side airbag system work?The design and development of the side airbag system includedrecommended testing procedures that were developed b
WARNING: Several air bag system components get hot afterinflation. Do not touch them after inflation.WARNING: If the sideairbag has deployed, theairba
WARNING: All occupants of the vehicle including the drivershould always wear their safety belts even when an airbag SRSand Safety Canopy威 system is pr
Low tire pressure warning:Illuminates when your tire pressureis low. If the light remains on atstart up or while driving, the tirepressure should be c
The Safety Canopy威 system, in combination with safety belts, can helpreduce the risk of severe injuries in the event of a significant side impactcolli
WARNING: If the Safety Canopy威 system has deployed, theSafety Canopy威 will not function again. The SafetyCanopy威 system (including the A, B and C pill
SAFETY RESTRAINTS FOR CHILDRENSee the following sections for directions on how to properly use safetyrestraints for children. Also see Airbag suppleme
Recommendations for Safety Restraints for ChildrenChild size, height, weight, or ageRecommendedrestraint typeInfants ortoddlersChildren weighing 40 lb
Recommendations for attaching child safety restraints for childrenRestraintTypeChildWeightUse any attachment method as indicatedbelow by “X”LATCH(lowe
WARNING: Never let a passenger hold a child on his or her lapwhile the vehicle is moving. The passenger cannot protect thechild from injury in a colli
If the child is the proper height, age, and weight (as specified by yourchild safety seat or booster manufacturer), fits the restraint and can berestr
Installing child safety seats with combination lap and shoulderbeltsIf needed, when installing some high back child restraints, the headrestraints of
• Keep the buckle release button pointing up and away from the safetyseat, with the tongue between the child seat and the release button,to help preve
3. While holding the shoulder andlap belt portions together, route thetongue through the child seataccording to the child seatmanufacturer’s instructi
Door ajar: Illuminates when theignition is in the on position and anydoor is open.Low fuel (if equipped):Illuminates when the fuel level inthe fuel ta
8. Remove remaining slack from thebelt. Force the seat down with extraweight, e.g., by pressing down orkneeling on the child restraint whilepulling up
however the safety belt can still be used to attach the child seat. Forforward-facing child seats, the top tether strap must also be attached tothe pr
WARNING: Never attach two child safety seats to the sameanchor. In a crash, one anchor may not be strong enough to holdtwo child safety seat attachmen
If the safety seat is not anchored properly, the risk of a child beinginjured in a crash greatly increases.Attaching child safety seats with tether st
2. Locate the correct anchor for theselected rear seating position.• You may need to pull the seatback forward to access the tetheranchors. Make sure
4. Clip the tether strap to theanchor and return the seat back toits locked position.If the tether strap is clippedincorrectly, the child safety seat
Although the lap/shoulder belt will provide some protection, childrenwho have outgrown a typical child seat are still too small for lap/shoulderbelts
Types of booster seatsThere are generally two types of belt-positioning booster seats: backlessand high back. Always use booster seats in conjunction
Children and booster seats vary in size and shape. Choose a booster thatkeeps the lap belt low and snug across the hips, never up across thestomach, a
Follow all instructions provided by the manufacturer of the booster seat.WARNING: Never place, or allow a child to place, the shoulderbelt under a chi
GAUGESSpeedometer: Indicates thecurrent vehicle speed.Engine coolant temperaturegauge: Indicates engine coolanttemperature. At normal operatingtempera
NOTICE TO UTILITY VEHICLE AND TRUCK OWNERSUtility vehicles and trucks handledifferently than passenger cars inthe various driving conditions thatare e
Power is supplied to all four wheels through a transfer case or powertransfer unit. 4WD vehicles allow you to select different drive modes asnecessary
• Narrower — to provide greatermaneuverability in tight spaces,particularly in off-road use.As a result of the above dimensionaldifferences, SUV’s and
TreadwearThe treadwear grade is a comparative rating based on the wear rate ofthe tire when tested under controlled conditions on a specifiedgovernmen
TIRESTires are designed to give many thousands of miles of service, but theymust be maintained in order to get the maximum benefit from them.Glossary
INFLATING YOUR TIRESSafe operation of your vehicle requires that your tires are properlyinflated. Remember that a tire can lose up to half of its air
The cold inflation pressure should never be set lower than therecommended pressure on the Safety Compliance Certification Label orTire Label.When weat
TIRE CAREInspecting your tires and wheel valve stemsPeriodically inspect the tire treads for uneven or excessive wear andremove objects such as stones
WARNING: AgeTires degrade over time depending on many factors such asweather, storage conditions, and conditions of use (load, speed,inflation pressur
WARNING: Only use replacement tires and wheels that are thesame size, load index, speed rating and type (such as P-metricversus LT-metric or all-seaso
Odometer: Registers the total miles (kilometers) of the vehicle.• Standard instrument cluster• Optional instrument clusterRefer to Message center in t
It is recommended that the two front tires or two rear tires generally bereplaced as a pair.The tire pressure sensors mounted in the wheels (originall
vehicle seems to pull to one side when you’re driving, the wheels may beout of alignment. Have an authorized dealer check the wheel alignmentperiodica
Note: Your vehicle may be equipped with a dissimilar spare tire/wheel. Adissimilar spare tire/wheel is defined as a spare tire and/or wheel that isdif
5. 15: Indicates the wheel or rim diameter in inches. If you change yourwheel size, you will have to purchase new tires to match the new wheeldiameter
numbers represent the week and year the tire was built. For example,the numbers 317 mean the 31st week of 1997. After 2000 the numbersgo to four digit
Additional information contained on the tire sidewall for “LT” typetires“LT” type tires have some additionalinformation beyond those of “P”type tires;
Information on “T” type tires“T” type tires have some additionalinformation beyond those of “P”type tires; these differences aredescribed below:T145/8
TIRE PRESSURE MONITORING SYSTEM (TPMS)Each tire, including the spare (ifprovided), should be checkedmonthly when cold and inflated tothe inflation pre
The Tire Pressure Monitoring System complies with part 15 of the FCCrules and with RSS-210 of Industry Canada. Operation is subject to thefollowing tw
Understanding your Tire Pressure Monitoring System (TPMS)The Tire Pressure Monitoring System measures pressure in your fourroad tires and sends the ti
Locks and Security 107Keys 107Locks 107Anti-theft system 118Seating and Safety Restraints 122Seating 122Safety restraints 132Airbags 147Child restrain
Fuel gauge: Indicatesapproximately how much fuel is leftin the fuel tank (when the ignitionis in the on position). The fuelgauge may vary slightly whe
When you believe your system is not operating properlyThe main function of the Tire Pressure Monitoring System is to warn youwhen your tires need air.
Low Tire PressureWarning LightPossible cause Customer Action RequiredFlashing WarningLightSpare tire in use Your temporary spare tire is inuse. Repair
SNOW TIRES AND CABLESWARNING: Snow tires must be the same size, load index, speedrating as those originally provided by Ford. The use ofnon-recommende
your vehicle, familiarize yourself with the following terms for determiningyour vehicle’s weight ratings, with or without a trailer, from the vehicle’
Example only:Cargo Weight – includes all weight added to the Base Curb Weight,including cargo and optional equipment. When towing, trailer tongue load
GAWR (Gross Axle Weight Rating) – is the maximum allowableweight that can be carried by a single axle (front or rear). Thesenumbers are shown on the S
• Example only:WARNING: Exceeding the Safety Compliance Certification Labelvehicle weight rating limits could result in substandard vehiclehandling or
GCW (Gross Combined Weight) – is the weight of the loaded vehicle(GVW) plus the weight of the fully loaded trailer.GCWR (Gross Combined Weight Rating)
WARNING: Exceeding any vehicle weight rating limitation couldresult in serious damage to the vehicle and/or personal injury.Steps for determining the
to transport the cement to your home? If you and your friend eachweigh 220 lb. (99 kg), the calculation would be: 1400 - (2 x 220) - (12x 100) = 1400
Remember to turn the ignition off when refueling to allow this feature tocorrectly detect the added fuel.The DTE function will display FUEL LEVEL LOW
TRAILER TOWINGTrailer towing with your vehicle may require the use of a trailer towoption package.Trailer towing puts additional loads on your vehicle
4x2GCWR (Gross Combined Weight Rating)/Trailer WeightEngine Rear axle ratio MaximumGCWR-lb. (kg)Trailer weightrange-lb. (kg)(0-Maximum)4.0L SOHC Class
4WD and AWDGCWR (Gross Combined Weight Rating)/Trailer WeightEngine Rear axle ratio MaximumGCWR-lb. (kg)Trailer weightrange-lb. (kg)(0-Maximum)4.0L SO
Safety chainsAlways connect the trailer’s safety chains to the frame or hook retainersof the vehicle hitch. To connect the trailer’s safety chains, cr
WARNING: Never connect any trailer lighting to the vehicle’staillamp circuits, because it may damage the electrical systemresulting in fire. Contact y
• If you are driving down a long or steep hill, shift to a lower gear. Donot apply the brakes continuously, as they may overheat and becomeless effect
CAMPER BODIESYour Explorer Sport Trac is not recommended for slide–in camperbodies.RECREATIONAL TOWINGFollow these guidelines if you have a need for r
STARTINGPositions of the ignition1. Off — shuts off the engine and allaccessories/locks the steering wheel,gearshift lever and allows keyremoval.2. Ac
WARNING: If you smell exhaust fumes inside your vehicle, haveyour dealer inspect your vehicle immediately. Do not drive if yousmell exhaust fumes.Impo
• Make sure the gearshift is in P(Park).3. Turn the key to 3 (on) withoutturning the key to 4 (start).Some warning lights will briefly illuminate. See
The following setup features are available:SYSTEM CHECK HOLD RESETPress and hold the SELECT/RESET stem to select system check whenthis is displayed in
Starting the engine1. Turn the key to 3 (on) withoutturning the key to 4 (start). If thereis difficulty in turning the key,rotate the steering wheel u
ENGINE BLOCK HEATER (IF EQUIPPED)An engine block heater warms the engine coolant which aids in startingand allows the heater/defroster system to respo
• Be sure that areas where the vehicle is parked are clean and clear ofall combustibles such as petroleum products, dust, rags, paper andsimilar items
brake pedal pulsation may be observed during ABS braking and thebrake pedal may suddenly travel a little farther as soon as ABS braking isdone and nor
The BRAKE warning lamp in theinstrument cluster illuminates andremains illuminated (when theignition is turned on) until theparking brake is released.
ADVANCETRAC姞 WITH ROLL STABILITY CONTROL™ (RSC姞)STABILITY ENHANCEMENT SYSTEMWARNING: Vehicle modifications involving braking system,aftermarket roof r
The AdvanceTrac威 with RSC威 system provides the following stabilityenhancement features for certain driving situations:• Traction Control (TCS), which
• If the driving condition is severe and your foot is not on the brake, thebrake pedal may move as the systems applies higher brake forces. Youmay als
Certain adverse driving maneuvers may activate the Electronic StabilityControl system, which include but are not limited to:• Taking a turn too fast•
with RSC威 system can be restored by pressing the AdvanceTrac威 withRSC威⬙Off⬙ button again or by turning off and restarting the engine.If you switch off
ENGLISH / SPANISH / FRENCH / JAPANESEAllows you to choose which language the message center will display in.Selectable languages are English, Spanish,
During Trailer Sway Control events, the icon in the instrumentcluster will flash momentarily. The message center will also displayTRAILER SWAY REDUCE
If the power steering system breaks down (or if the engine is turnedoff), you can steer the vehicle manually, but it takes more effort. If thesteering
BRAKE-SHIFT INTERLOCKThis vehicle is equipped with a brake-shift interlock feature that preventsthe gearshift lever from being moved from P (Park) whe
AUTOMATIC TRANSMISSION OPERATIONDriving with a 5–speed automatic transmission (if equipped)This vehicle is equipped with an Adaptive Transmission Cont
N (Neutral)With the gearshift lever in N (Neutral), the vehicle can be started and isfree to roll. Hold the brake pedal down while in this position.D
1 (First)• Provides maximum engine braking.• Allows upshifts by moving gearshift lever.• Will not downshift into 1 (First) at high speeds; allows for
P (Park)This position locks the transmissionand prevents the rear wheels fromturning.To put your vehicle in gear:• Press the brake pedal• Start the en
D (Drive) without OverdriveOverdrive can be deactivated bypressing the transmission controlswitch on the side of the shift lever.• This position allow
• Allows upshifts by moving gearshift lever.• Will not downshift into 1 (First) at high speeds; allows for 1 (First)when vehicle reaches slower speeds
WARNING: Certain add-on devices such as large trailer hitches,bike or surfboard racks and any device that may block thenormal detection zone of the RS
TRAILER SWAYThis feature uses the electronic stability control to mitigate trailer sway,1. Press and hold the SELECT/RESET stem to turn trailer sway o
Keep the RSS sensors (located on the rear bumper/fascia) freefrom snow, ice and large accumulations of dirt (do not clean thesensors with sharp object
Using the Control Trac 4WD system4X4 AUTO - Provideselectronically-controlled four-wheeldrive with power delivered to allfour wheels as required for t
WARNING: If your vehicle is equipped with AWD, a spare tire ofa different size than the road tires should never be used. Such atire could make the veh
How your vehicle differs from other vehiclesTruck and utility vehicles can differ from some other vehicles. Yourvehicle may be higher to allow it to t
• It often may be less risky to strike small objects, such as highwayreflectors, with minor damage to your vehicle rather than attempt asudden return
Emergency maneuvers• In an unavoidable emergency situation where a sudden sharp turnmust be made, remember to avoid “over-driving” your vehicle, i.e.,
ParkingOn some 4WD vehicles, when the transfer case is in the N (Neutral)position, the engine and transmission are disconnected from the rest ofthe dr
Mud and waterIf you must drive through highwater, drive slowly. Traction orbrake capability may be limited.When driving through water,determine the de
Driving on hilly or sloping terrainAlthough natural obstacles may make it necessary to travel diagonally upor down a hill or steep incline, you should
Driving on snow and iceAWD and 4WD vehicles have advantages over 2WD vehicles in snow andice but can skid like any other vehicle.Should you start to s
degrees between adjacent zones and will become noticeable as thevehicle crosses multiple zones. A correct zone setting will eliminate thiserror. Do th
Any modifications to a vehicle that raise the center of gravity can makeit more likely the vehicle will roll over as a result of a loss of control.For
ROADSIDE ASSISTANCEGetting roadside assistanceTo fully assist you should you have a vehicle concern, Ford MotorCompany offers a complimentary roadside
• towing of your disabled vehicle• emergency travel expense reimbursement• travel planning benefitsIn Canada, for uninterrupted Roadside Assistance co
FUEL PUMP SHUT-OFF SWITCHFUELRESETThe fuel pump shut-off switch is a device intended to stop the electricfuel pump when your vehicle has been involved
FUSES AND RELAYSFusesIf electrical components in thevehicle are not working, a fuse mayhave blown. Blown fuses areidentified by a broken wire withinth
Passenger compartment fuse panelThe fuse panel is located below theinstrument panel on the driver’sside.To remove a fuse use the fuse puller tool prov
Fuse/RelayLocationFuse AmpRatingProtected Circuits5 5A Moon roof, Power down backwindow, Door lock switchillumination, Auto dimming rearview mirror6 2
Fuse/RelayLocationFuse AmpRatingProtected Circuits22 15A Brake switch, Stop lamps, Turnlamps23 15A Interior lamps, Puddle lamps,Cargo lamp, Battery sa
The high-current fuses are coded as follows:Fuse/RelayLocationFuse AmpRatingProtected Circuits1 50A** Battery feed 2 (passengercompartment fuse panel)
Fuse/RelayLocationFuse AmpRatingProtected Circuits13 30A** Trailer tow battery charge14 40A ** Power drivers seat15 40A** Heated mirror16 40A** Blower
3. Press and hold the SELECT/RESET stem until the message centerdisplays HOLD RESET FOR SYSTEM CHECK. Do not hold the stemdown at this point as you do
Fuse/RelayLocationFuse AmpRatingProtected Circuits40 15A* Fan clutch, Positive crackcaseventilation (PCV) valve, A/C clutchrelay41 15A* Satellite radi
CHANGING THE TIRESIf you get a flat tire while driving:• do not brake heavily.• gradually decrease the vehicle’s speed.• hold the steering wheel firml
2. Full-size dissimilar spare with label on wheel: This spare tire hasa label on the wheel that states: “THIS TIRE AND WHEEL FORTEMPORARY USE ONLY”Whe
• Wet weather driving capability• All-Wheel driving capability (if applicable)• Load leveling adjustment (if applicable)When driving with the full-siz
Removing the jack and tools1. Fold the passenger side rear seatforward, then remove the jack.2. Turn the jack screw eyelet (1)counterclockwise to rele
2. Insert the square end of the jackhandle extension into the rearaccess hole located just above therear bumper and below the tailgate.Forward motion
WARNING: Do not attempt to change a tire on the side of thevehicle close to moving traffic. Pull far enough off the road toavoid the danger of being h
5. Position the jack according to theillustrated guides and turn the jackhandle clockwise until the tire is amaximum of 1 inch (25 mm) off theground.W
9. Remove the jack and fully tightenthe lug nuts in the order shown.Refer to Wheel lug nut torquespecifications later in this chapterfor the proper lu
2. Stow the wheel ornament (if removed) in a safe location in the vehicle(such as the glove box or jack stowage compartment) so it will notbecome dama
DOOR AJAR — Displayed when a door is not completely closed.REMOVE OBJECTS NEAR PASS SEAT — Displayed when objectsare by the passenger seat. After the
JUMP STARTINGWARNING: The gases around the battery can explode ifexposed to flames, sparks, or lit cigarettes. An explosion couldresult in injury or v
Connecting the jumper cables1. Connect the positive (+) jumper cable to the positive (+) terminal ofthe discharged battery.Note: In the illustrations,
3. Connect the negative (-) cable to the negative (-) terminal of theassisting battery.4. Make the final connection of the negative (-) cable to the g
Note: Do not attach the negative (-) cable fuel lines, engine rockercovers, the intake manifold or electrical components as groundingpoints.WARNING: D
3. Remove the jumper cable from the positive (+) terminal of the boostervehicle’s battery.4. Remove the jumper cable from the positive (+) terminal of
WRECKER TOWINGIf you need to have your vehicle towed, contact a professional towingservice or, if you are a member of a roadside assistance program, y
Ford Motor Company produces a towing manual for all authorized towtruck operators. Have your tow truck operator refer to this manual forproper hook-up
GETTING THE SERVICES YOU NEEDWarranty repairs to your vehicle must be performed by an authorizedFord, Lincoln, or Mercury dealer. While any authorized
In Canada:Mailing address (Ford vehicles)Customer Relationship CentreFord Motor Company of Canada, LimitedP.O. Box 2000Oakville, Ontario L6J 5E4Teleph
In the United States, a warranty dispute must be submitted to the BBBAUTO LINE before taking action under the Magnuson-Moss WarrantyAct, or to the ext
BRAKE FLUID LEVEL LOW — Indicates the brake fluid level is lowand the brake system should be inspected immediately. Refer to BrakeFluid in the Mainten
THE BETTER BUSINESS BUREAU (BBB) AUTO LINE PROGRAM(U.S. ONLY)Your satisfaction is important to Ford Motor Company and to your dealer.If a warranty con
UTILIZING THE MEDIATION/ARBITRATION PROGRAM(CANADA ONLY)For vehicles delivered to authorized Canadian dealers. In those caseswhere you continue to fee
If your vehicle must be serviced while you are traveling or living inCentral America, the Caribbean, or the Middle East, contact the nearestauthorized
REPORTING SAFETY DEFECTS (U.S. ONLY)If you believe that your vehicle hasa defect which could cause a crashor could cause injury or death, youshould im
WASHING THE EXTERIORWash your vehicle regularly with cool or lukewarm water and a neutralpH shampoo, such as Motorcraft Detail Wash (ZC-3-A), which is
• After polishing chrome bumpers, apply a coating of MotorcraftPremium Liquid Wax (ZC-53-A), available from your authorized dealer,or an equivalent qu
ENGINEEngines are more efficient when they are clean because grease and dirtbuildup keep the engine warmer than normal. When washing:• Take care when
4.6L V8 ENGINEPLASTIC (NON-PAINTED) EXTERIOR PARTSUse only approved products to clean plastic parts. These products areavailable from your authorized
• The wiper blades can be cleaned with isopropyl (rubbing) alcohol orMotorcraft Premium Windshield Washer Concentrate (ZC-32-A),available from your au
If a staining liquid like coffee/juice has been spilled on the instrumentpanel or on interior trim surfaces, clean as follows:1. Wipe up spilled liqui
The message center display is located in the instrument cluster.Your display can show up to six reconfigurable telltales at one time.Whatever is displ
LEATHER SEATS (IF EQUIPPED)Your leather seating surfaces have a clear, protective coating over theleather.• For routine cleaning, wipe the surface wit
Motorcraft Premium Glass Cleaner (Canada only) (CXC-100)Motorcraft Premium Liquid Wax (ZC-53-A)Motorcraft Premium Windshield Washer Concentrate (U.S.
SERVICE RECOMMENDATIONS• Use the scheduled maintenance information to track routineservice.• Use only recommended fuels, lubricants, fluids and servic
OPENING THE HOOD1. Inside the vehicle, pull the hoodrelease handle located under thebottom left corner of the instrumentpanel.2. Go to the front of th
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT4.0L V6 engine1. Engine oil filler cap2. Engine oil dipstick (out of view)3. Brake fluid reservoir4. P
4.6L V8 engine1. Air filter assembly2. Engine oil filler cap3. Engine oil dipstick4. Brake fluid reservoir5. Power distribution box6. Battery7. Power
WINDSHIELD WASHER FLUIDAdd fluid to fill the reservoir if thelevel is low. In very cold weather, donot fill the reservoir completely.Only use a washer
CHANGING THE WIPER BLADES1. Pull the wiper arm away from thevehicle. Turn the blade at an anglefrom the wiper arm. Push the lockpin manually to releas
• 4.0L V6 engine• 4.6L V8 engine6. Wipe the dipstick clean. Insert the dipstick fully, then remove it again.• If the oil level is between the lower an
• 4.0L V6 engine• 4.6L V8 engine• Oil levels above the upper hole may cause engine damage. Some oilmust be removed from the engine by an authorized de
Customer Assistance 277Reporting safety defects (U.S. only) 283Reporting safety defects (Canada only) 283Cleaning 284Maintenance and Specifications 29
The DTE function will display LOW FUEL LEVEL when you haveapproximately 50 miles (80 km), to empty. Press RESET to clear thiswarning message. It will
To avoid possible oil loss, DO NOT operate the vehicle with theengine oil level dipstick and/or the engine oil filler cap removed.Engine Oil Recommend
4.6L 3V V8 EngineLook for this certificationtrademark.Use SAE 5W-20 engine oilOnly use oils “Certified For Gasoline Engines” by the AmericanPetroleum
BATTERYYour vehicle is equipped with aMotorcraft maintenance-free batterywhich normally does not requireadditional water during its life ofservice.If
WARNING: Keep batteries out of reach of children. Batteriescontain sulfuric acid. Avoid contact with skin, eyes or clothing.Shield your eyes when work
• Always dispose of automotivebatteries in a responsible manner.Follow your local authorizedstandards for disposal. Call yourlocal authorized recyclin
• 4.0L V6 engine• 4.6L V8 engine• The engine coolant should be at the FULL COLD level or within theCOLD FILL RANGE as listed on the engine coolant res
Adding engine coolantWhen adding coolant, make sure it is a 50/50 mixture of engine coolantand distilled water. Add the mixture to the coolant reservo
WARNING: To reduce the risk of personal injury, make sure theengine is cool before unscrewing the coolant pressure relief cap.The cooling system is un
Used engine coolant should be disposed of in an appropriatemanner. Follow your community’s regulations and standards for recyclingand disposing of aut
What you should know about fail-safe cooling(4.6L V8 engine only)If the engine coolant supply is depleted, this feature allows the vehicle tobe driven
DRIVE TIMETimer displays the trip elapsed drive time.To operate, do the following:1. Press and release RESET in order to start the timer.2. Press and
When fail-safe cooling mode is activatedYou have limited engine power when in the fail-safe mode, so drive thevehicle with caution. Remember that the
WARNING: If you do not use the proper fuel filler cap,excessive vacuum in the fuel tank may damage the fuel systemor cause the fuel cap to disengage i
• Be particularly careful if you are taking “Antabuse” or other forms ofdisulfiram for the treatment of alcoholism. Breathing gasoline vapors,or skin
Fuel filler capWhen fueling your vehicle:1. Turn the engine off.2. Carefully turn the filler cap counterclockwise until it spins off.3. Pull to remove
WARNING: If you do not use the proper fuel filler cap,excessive vacuum in the fuel tank may damage the fuel systemor cause the fuel cap to disengage i
Fuel qualityIf you are experiencing starting, rough idle or hesitation driveabilityproblems, try a different brand of unleaded gasoline. If the proble
ESSENTIALS OF GOOD FUEL ECONOMYMeasuring techniquesYour best source of information about actual fuel economy is you, thedriver. You must gather inform
Calculating fuel economy1. Fill the fuel tank completely and record the initial odometer reading(in miles or kilometers).2. Each time you fill the tan
• You may want to turn off the speed control in hilly terrain ifunnecessary shifting between the top gears occurs. Unnecessaryshifting of this type co
EPA fuel economy estimatesEvery new vehicle should have a sticker on the window called theMonroney Label which contains EPA fuel economy estimates. Co
UNITSDisplays the current units in English or Metric.Press the RESET button to change from English to Metric.LANGUAGE ENGLISH / SPANISH / FRENCH / JAP
WARNING: Exhaust leaks may result in entry of harmful andpotentially lethal fumes into the passenger compartment.Do not make any unauthorized changes
If the service engine soon indicator remains on, have your vehicleserviced at the first available opportunity. Although some malfunctionsdetected by t
POWER STEERING FLUIDCheck the power steering fluid. Refer to scheduled maintenanceinformation.1. Start the engine and let it rununtil it reaches norma
TRANSMISSION FLUIDChecking automatic transmission fluidThe automatic transmission does not have an underhood transmissionfluid dipstick.Refer to your
DRIVELINE UNIVERSAL JOINT AND SLIP YOKEIf the original universal joints are replaced with universal joints equippedwith grease fittings, lubrication w
2. Carefully separate the two halves of the air filter housing.3. Remove the air filter element from the air filter housing.4. Wipe the air filter hou
MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIESItem CapacityFord Part Nameor equivalentFord Part Number / FordSpecificationBrake fluidBetween MINand
Item CapacityFord Part Nameor equivalentFord Part Number / FordSpecificationCooling systemstop leak pellets—Motorcraft CoolingSystem Stop LeakPelletsV
Item CapacityFord Part Nameor equivalentFord Part Number / FordSpecificationEngine oil(4.6L engine)6.0 quarts(5.7L)•Motorcraft SAE5W-20 PremiumSynthet
Item CapacityFord Part Nameor equivalentFord Part Number / FordSpecificationRear axle fluid 3.5 pints (1.7L)Motorcraft SAE75W-140 SyntheticRear Axle L
TRAILER SWAYThis feature uses the electronic stability control to mitigate trailer sway,Press the RESET button to turn trailer sway on or off.COMPASS
Item CapacityFord Part Nameor equivalentFord Part Number / FordSpecificationFuel tank22.5 gallons(85.2L)——1Add the coolant type originally equipped in
ENGINE DATAEngine 4.0L V6 engine 4.6L 3V V8engineCubic inches 245 281Required fuel 87 octane 87 octaneFiring order 1-4-2-5-3-6 1-3-7-2-6-5-4-8Ignition
IDENTIFYING YOUR VEHICLESafety Compliance Certification LabelThe National Highway Traffic SafetyAdministration Regulations requirethat a Safety Compli
The Vehicle Identification Number (VIN) contains the followinginformation:1. World manufacturer identifier2. Brake system / Gross VehicleWeight Rating
GENUINE FORD ACCESSORIES FOR YOUR VEHICLEA wide selection of Genuine Ford Accessories are available for yourvehicle through your local Ford or Ford of
Peace of mindRemote startVehicle security systemsLocking gas plug for capless fuel systemWheel locksFor maximum vehicle performance, keep the followin
FORD ESP EXTENDED SERVICE PLANSMore than 30 million Ford, Lincoln, and Mercury owners have discoveredthe powerful protection of Ford ESP. It is the on
Ford ESP Can Quickly Pay for ItselfOne service bill – the cost of parts and labor – can easily exceed theprice of your Ford ESP Service Contract. With
Ford Extended Service Plan3382010 07+ Explorer Sport Trac (esp)Owners Guide (own2002), 1st PrintingUSA (fus)
AAccessory delay ...88AdvanceTrac ...225Air cleaner filter ...324–325Air conditioning ..
PRESS RESET FOR CALIBRATIONPerform compass calibration in an open area free from steel structuresand high voltage lines. For optimum calibration, turn
Child safety seats - boosterseats ...176Cleaning your vehicleengine compartment ...286instrument pa
Engine block heater ...221Engine oil ...297checking and adding ...297dipstick ...
Inspection/maintenance (I/M)testing ...321Instrument panelcleaning ...288cluster
Pedals (see Power adjustablefoot pedals) ...92Power adjustable foot pedals ...92Power distribution box(see Fuses) ...
Speed control ...92Starting yourvehicle ...217–218, 220jump starting ...270Stee
• Some messages will appear once and then again when the vehicle isrestarted.• Some messages will reappear after clearing or being reset if a problemo
TIRE PRESSURE SENSOR FAULT — Displayed when a tire pressuresensor is malfunctioning, or your spare tire is in use. For moreinformation on how the syst
AUDIO SYSTEMSQuick start — How to get goingWARNING: Driving while distracted can result in loss of vehiclecontrol, accident and injury. Ford strongly
Listening to satellite radio (if equipped)1. If the audio system is turned off,press VOL-PUSH to turn the radioon. Turn VOL-PUSH to adjust thevolume.N
For a single CD system, if a discis not already loaded, insert onlyone, label side up into the CD slot.LOADING CD and READING DISC will appear in the
CONGRATULATIONSCongratulations on acquiring your new Ford. Please take the time to getwell acquainted with your vehicle by reading this handbook. The
While in folder mode, pressFOLDER to access the nextfolder on MP3 discs, if available.Press SHUFFLE to engage shufflemode. SHUFFLE ON will appear inth
AM/FM Single CD/MP3 satellite compatible sound system(if equipped)WARNING: Driving while distracted can result in loss of vehiclecontrol, accident and
In CATEGORY MODE, press / to scroll through the list ofavailable SIRIUS channel Categories (Pop, Rock, News, etc.). Refer toCategory Mode under Menu f
• DELETE SONG: Press OK to delete a song from the system’smemory. Press/ to cycle through the saved songs. When thesong appears in the display that yo
To activate, press MENU repeatedly until RBDS (ON/OFF) appears inthe display. Use / / SEEK to toggle RBDS ON/OFF. WhenRBDS is OFF, you will not be abl
TRACK/FOLDER MODE: Available only on MP3 discs in CD mode.In track mode, pressSEEK, SEEK to scroll through all tracks onthe discIn folder mode, pressS
6. / (Play/Pause): Thiscontrol is operational in CD andDVD mode (if equipped). When aCD or DVD is playing in the FES system, press this control to pla
PRESET # SAVED appears in the display. You can save up to 18 stations,six in AM, six in FM1 and FM2.In satellite radio mode (if equipped), there are 1
16. CD: Press to enter CD/MP3mode. If a CD/MP3 is already loadedinto the system, CD/MP3 play willbegin where it ended last. If no CD is loaded, NO DIS
Accessory delay: Your vehicle is equipped with accessory delay. Withthis feature, the window switches, radio and moon roof (if equipped)may be used fo
Warning symbols on your vehicleWhen you see this symbol, it isimperative that you consult therelevant section of this guide beforetouching or attempti
• SAVE SONG: Press OK to save the currently playing song’s title inthe system’s memory. (If you try to save something other than a song,CANT SAVE will
AUTOSET: Press MENU until the display reads AUTOSET. Autosetallows you to set the strongest local radio stations without losing youroriginal manually
The default setting is off; increasing your vehicle speed will not changethe volume level.Adjust 1–7: Increasing this setting from 1 (lowest setting)
If your vehicle is equipped with a Family Entertainment System (FES)please refer to the Family Entertainment DVD system later in thischapter.If your v
Note: In track mode, all tracks on the current disc will shuffle inrandom order. In MP3 folder mode, the system will randomly play alltracks within th
Press and hold to hear a brief sampling of the next channels. Press againto stop.In CATEGORY MODE, press SCAN to hear a brief sampling of thechannels
18. (CD eject): To eject a discfrom the system, press . Selectthe correct slot number usingmemory presets 1–6. When ready, the system will eject the d
Required equipment:1. Any portable music player designed to be used with headphones2. An audio extension cable with stereo male 1/8 in. (3.5 mm)connec
5. For safety reasons, connecting or adjusting the settings on yourportable music player should not be attempted while the vehicle ismoving. Also, the
• Station overload: When you pass a broadcast tower, a stronger signalmay overtake a weaker one and play while the weak station frequencyis displayed.
Do not add friction modifier compounds or special break-in oils sincethese additives may prevent piston ring seating. See Engine oil in theMaintenance
CDs with homemade paper(adhesive) labels should not beinserted into the CD player asthe label may peel and cause theCD to become jammed. It isrecommen
Sample MP3 structureIf you are burning your own MP3discs, it is important to understandhow the system will read thestructures you create. While variou
• Terrain: Hills, mountains, tall buildings, bridges, tunnels, freewayoverpasses, parking garages, dense tree foliage and thunderstorms caninterfere w
Radio Display Condition Action RequiredACQUIRING Radio requires morethan two seconds toproduce audio forthe selectedchannel.No action required. Thisme
Radio Display Condition Action RequiredNO TEXT Categoryinformation notavailable.Category information notavailable at this time onthis channel. The sys
MANUAL HEATING AND AIR CONDITIONING SYSTEM(IF EQUIPPED)1. Temperature selection:Controls the temperature of theairflow in the vehicle.2. Air flow sele
• Remove any snow, ice or leaves from the air intake area at the base ofthe windshield.• To improve the A/C cool down when the vehicle interior issign
DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) SYSTEM(IF EQUIPPED)1. A/C control: Press to turn onthe air conditioning. Press again toturn off the air cond
4. MAX A/C: Distributesrecirculated air through theinstrument panel vents to cool thevehicle. This recooling of theinterior air is more economical and
14. Driver’s side temperaturecontrol: Press to increase ordecrease the temperature on thedriver side of the cabin. This controlalso sets the passenger
Your vehicle is not equipped with the Ford Ambulance PreparationPackage.NOTICE TO OWNERS WITH 20 INCH WHEELS AND TIRESWhen equipped with 20 inch wheel
For maximum cooling performance:• Select and A/C and recirculated air. Use recirculated air with A/C toprovide a cooler airflow.• Move the temperature
HEADLAMP CONTROLTurns the lamps off.Turns on the parking lamps,instrument panel lamps, licenseplate lamps and tail lamps.Turns the headlamps on.Autola
Fog lamp controlThe fog lamps can be turned ononly when the headlamp control isin the, or position andthe high beams are not turned on.Pull headlamp c
Flash to passPull the lever toward you toactivate. Release the lever todeactivate.PANEL DIMMER CONTROLUse to adjust the brightness of theinstrument pa
To adjust the headlamps:1. Park your vehicle on a level surface about 25 feet (7.6 meters) awayfrom a vertical plain surface (3). Check your headlamp
TURN SIGNAL CONTROL• Push down to activate the leftturn signal.• Push up to activate the right turnsignal.INTERIOR LAMPSMap lampsThe front map lamps a
Examples of acceptable condensation are:• Presence of thin mist (no streaks, drip marks or droplets)• Fine mist covers less than 50% of the lensExampl
Function Number of bulbs Trade numberFront door courtesylamp1168Map lamps 2 168 (T10)Ashtray lamp 1 161Visor vanity lamp -Slide on rail system(SOR)2A6
3. Disconnect the electricalconnector.4. Remove the old bulb by turningcounterclockwise and pull it out.WARNING: Handle a halogen headlamp bulb carefu
Replacing tail/brake/turn/backup lamp bulbs1. Turn the headlamp switch off andopen the tailgate.2. Remove the two bolts from thelamp assembly.3. Remov
• how far (if at all) the driver was depressing the acceleratorand/or the brake pedal;• how fast the vehicle was traveling;• where the driver was posi
Replacing license plate lamp bulbsThe license plate bulbs are locatedbehind the rear bumper. To changethe license plate lamp bulbs:1. Reach behind the
MULTI-FUNCTION LEVERWindshield wiper: Rotate the endof the control away from you toincrease the speed of the wipers;rotate towards you to decrease the
TILT STEERING COLUMNPull the lever down and release, tounlock the steering column tilt lock.With the lever in the down position,tilt the steering colu
Slide on rod featureRotate the visor towards the sidewindow and extend it rearward foradditional sunlight coverage.Note: To stow the visor back intoth
Installing a garage door opener (if equipped)The storage compartment can be converted to accommodate a variety ofaftermarket garage door openers:• Pla
To prevent the fuse from being blown, do not use the power point(s)over the vehicle capacity of 12 VDC/180W. If the power point or cigarlighter socket
The rear side of the console may incorporate the following features:• Air vents• CupholdersWARNING: Use only soft cups in the cupholder. Hard objectsc
To operate one touch down:• Press the switch completely downto the second detent and releasequickly. The window will openfully. Momentarily press thes
Window lockThe window lock feature allows onlythe driver to operate the powerwindows.To lock out all the window controls(except for the driver’s) pres
WARNING: Do not leave children unattended in the vehicle anddo not let children play with the power sliding back window.They may seriously injure them
CELL PHONE USEThe use of Mobile Communications Equipment has become increasinglyimportant in the conduct of business and personal affairs. However,dri
INTERIOR MIRRORThe interior rear view mirror has two pivot points on the support armwhich lets you adjust the mirror up or down and from side to side.
To adjust your mirrors:1. Rotate the control clockwise toadjust the right mirror and rotatethe control counterclockwise toadjust the left mirror.2. Mo
Do not remove ice from themirrors with a scraper orattempt to readjust the mirrorglass if it is frozen in place.These actions could causedamage to the
Setting speed controlThe controls for using your speedcontrol are located on the steeringwheel for your convenience.1. Press the ON control and releas
Resuming a set speedPress the RES (resume) control andrelease it. This will automaticallyreturn the vehicle to the previouslyset speed.Increasing spee
Turning off speed controlThere are two ways to turn off the speed control:• Press the brake pedal. This will not erase your vehicle’s previously setsp
In CD or USB mode (if equipped):• PressSEEK to select the next selection on the CD/USBor press and hold to forward or reverse through the CD/USB.In an
For further information on the SYNC威 system, refer to the SYNC威supplement.Navigation system/SYNC威 handsfree control features (ifequipped)Press VOICE b
To open the moon roof: Press andrelease the SLIDE control, the moonroof will open automatically. Pressthe switch again to stop the moonroof.To close t
TAILGATE LOCKThe tailgate lock is designed to helpprevent theft of the tailgate.• Insert ignition key and turn to theright to lock.• Turn ignition key
Kommentare zu diesen Handbüchern