Ford 2012 Transit Connect Bedienungsanleitung

Introduction 4Instrument Cluster 14Warning lights and chimes 14Gauges 19Entertainment Systems 23AM/FM stereo 23AM/FM stereo with CD 26Auxiliary input

CELL PHONE USEThe use of Mobile Communications Equipment has become increasinglyimportant in the conduct of business and personal affairs. However,dri

WARNING: Safety belts and seats can become hot in a vehiclethat has been closed up in sunny weather; they could burn asmall child. Check seat covers a

Restraint of pregnant womenWARNING: Always ride and drive with your seatback uprightand the safety belt properly fastened. The lap portion of thesafet

When to use the automatic locking modeThis mode should be used any time a child safety seat, except abooster, is installed in passenger front or rear

Safety belt pretensionerYour vehicle is equipped with safety belt pretensioners at the driver andfront outboard passenger seating positions.The safety

WARNING: Position the safety belt height adjusters so that thebelt rests across the middle of your shoulder. Failure to adjustthe safety belt properly

Both the driver’s and passenger’s safety belt usages are monitored andeither may activate the Belt-Minder威 feature. The warnings are the samefor the d

The following are reasons most often given for not wearing safety belts(All statistics based on U.S. data):Reasons given... Consider...“Crashes are ra

Reasons given... Consider...“I have an airbag” Airbags offer greater protection whenused with safety belts. Frontal airbagsare not designed to inflate

• Step 3 must be completed within 50 seconds after the safety beltwarning light turns off.3. Buckle then unbuckle the driver’s safety belt nine times

WARNING: Always transport children 12 years old and under ina rear seating position, and always properly use appropriate childrestraints. Never place

EXPORT UNIQUE (NON–UNITED STATES/CANADA) VEHICLESPECIFIC INFORMATIONFor your particular global region, your vehicle may be equipped withfeatures and o

Children and airbagsChildren must always be properlyrestrained. Accident statisticssuggest that children are safer whenproperly restrained in the rear

The airbags inflate and deflaterapidly upon activation. After airbagdeployment, it is normal to notice asmoke-like, powdery residue orsmell the burnt

WARNING: If the air bag has deployed, the air bag will notfunction again and must be replaced immediately. If the airbag is not replaced, the unrepair

Note: The indicator lamp will illuminate for a short period of time whenthe ignition is turned to the on position to confirm it is functional.When the

OccupantPass Airbag OffIndicator LampPassenger AirbagEmpty seat Unlit DisabledSmall child in childsafety seat or boosterLit DisabledSmall child with s

ObjectsPass Airbag OffIndicator LampPassenger AirbagSmall (i.e. three-ringbinder, small purse,bottled water)Unlit DisabledMedium (i.e. heavybriefcase,

In case there is a problem with thefront passenger sensing system, theairbag readiness lamp in theinstrument cluster will stay lit.If the airbag readi

A difficulty with the system is indicated by one or more of the following:• The readiness light will eitherflash or stay lit.• The readiness light wil

How does the side airbag system work?The design and development of theside airbag system includedrecommended testing proceduresthat were developed by

WARNING: Several air bag system components get hot afterinflation. Do not touch them after inflation.WARNING: If the sideairbag has deployed, theairba

These are some of the symbols you may see on your vehicle.Vehicle Symbol GlossarySafety AlertSee Owner’s GuideFasten Safety Belt Airbag - FrontAirbag

SAFETY RESTRAINTS FOR CHILDRENSee the following sections for directions on how to properly use safetyrestraints for children. Also see Airbag suppleme

Recommendations for Safety Restraints for ChildrenChild size, height, weight, or ageRecommendedrestraint typeInfants ortoddlersChildren weighing 40 lb

Recommendations for attaching child safety restraints for childrenRestraintTypeChildWeightUse any attachment method as indicatedbelow by “X”LATCH(lowe

WARNING: Never let a passenger hold a child on his or her lapwhile the vehicle is moving. The passenger cannot protect thechild from injury in a colli

Follow all the safety restraint and airbag precautions that apply to adultpassengers in your vehicle.If the child is the proper height, age, and weigh

position whenever possible. If all children cannot be seated andrestrained properly in a rear seating position, properly restrain thelargest child in

2. Pull down on the shoulder beltand then grasp the shoulder beltand lap belt together.3. While holding the shoulder andlap belt portions together, ro

5. To put the retractor in theautomatic locking mode, grasp theshoulder portion of the belt and pulldownward until all of the belt ispulled out.6. All

10. Before placing the child in theseat, forcibly move the seat forwardand back to make sure the seat issecurely held in place. To checkthis, grab the

• Taxi version• All othersThe LATCH lower anchors arelocated at the rear section of therear seat between the cushion andseatback, below the locator sy

Vehicle Symbol GlossaryPower WindowsFront/RearPower Window LockoutChild Safety DoorLock/UnlockInterior LuggageCompartment ReleasePanic Alarm Engine Oi

WARNING: Depending on where you secure a child restraint,and depending on the child restraint design, you may blockaccess to certain safety belt buckl

Attaching child safety seats with tether strapsMany forward-facing child safety seats include a tether strap whichextends from the back of the child s

Perform the following steps to install a child safety seat with tetheranchors:Front passenger seating positionThe tether can be attached directly to t

3. Clip the tether strap to theanchor as shown.Second-row outboard seating positions1. Remove the head restraint. For instructions on how to remove th

3. Clip the tether strap to theanchor as shown.If the tether strap is clipped incorrectly, the child safety seat may not beretained properly in the ev

Booster seats position a child so that vehicle lap/shoulder safety belts fitbetter. They lift the child up so that the lap belt rests low across the h

Types of booster seatsThere are generally two types of belt-positioning booster seats: backlessand high back. Always use booster seats in conjunction

Children and booster seats vary in size and shape. Choose a booster thatkeeps the lap belt low and snug across the hips, never up across thestomach, a

Follow all instructions provided by the manufacturer of the booster seat.WARNING: Never place, or allow a child to place, the shoulderbelt under a chi

NOTICE TO UTILITY VEHICLE AND TRUCK OWNERSUtility vehicles and trucks handledifferently than passenger cars inthe various driving conditions thatare e

WARNING LIGHTS AND CHIMESStandard instrument cluster shown; metric clusters similarWarning lights and gauges can alert you to a vehicle condition that

VEHICLE CHARACTERISTICSHow your vehicle differs from other vehiclesSUVs and trucks can differ fromsome other vehicles in a fewnoticeable ways. Your ve

INFORMATION ABOUT UNIFORM TIRE QUALITY GRADINGTire Quality Grades apply to newpneumatic passenger car tires. TheQuality grades can be found whereappli

WARNING: The traction grade assigned to this tire is based onstraight-ahead braking traction tests, and does not includeacceleration, cornering, hydro

• kPa: Kilopascal, a metric unit of air pressure.• PSI: Pounds per square inch, a standard unit of air pressure.• Cold inflation pressure: The tire pr

Always inflate your tires to the Ford recommended inflation pressureeven if it is less than the maximum inflation pressure information foundon the tir

5. Repeat this procedure for each tire, including the spare.Note: Some spare tires operate at a higher inflation pressure than theother tires. For T-t

Improper or inadequate vehicle maintenance can cause tires to wearabnormally. Inspect all your tires, including the spare, frequently, andreplace them

U.S. DOT Tire Identification Number (TIN)Both U.S. and Canada Federal regulations require tire manufacturers toplace standardized information on the s

WARNING: When mounting replacement tires and wheels, youshould not exceed the maximum pressure indicated on thesidewall of the tire to set the beads w

• Do not run over curbs or hit the tire against a curb when parkingWARNING: If your vehicle is stuck in snow, mud, sand, etc., donot rapidly spin the

WARNING: Under engine misfire conditions, excessive exhausttemperatures could damage the catalytic converter, the fuelsystem, interior floor coverings

• Front-wheel drive (FWD) vehicles(front tires at top of diagram)Sometimes irregular tire wear can be corrected by rotating the tires.Note: If your ti

Information on “P” type tiresP215/65R15 95H is an example of atire size, load index and speedrating. The definitions of theseitems are listed below. (

Note: You may not find this information on all tires because it is notrequired by federal law.Letter rating Speed rating - mph (km/h)M 81 mph (130 km/

12. Treadwear, Traction and Temperature Grades• Treadwear: The treadwear grade is a comparative rating based on thewear rate of the tire when tested u

Additional information contained on the tire sidewall for “LT” typetires“LT” type tires have some additionalinformation beyond those of “P”type tires;

Information on “T” type tires“T” type tires have some additionalinformation beyond those of “P”type tires; these differences aredescribed below:T145/8

TIRE PRESSURE MONITORING SYSTEM (TPMS)Each tire, including the spare (ifprovided), should be checkedmonthly when cold and inflated tothe inflation pre

following two conditions: (1) This device may not cause harmfulinterference, and (2) This device must accept any interference received,including inter

To restore the full functionality of the tire pressure monitoring system,have the damaged road wheel/tire repaired and remounted on yourvehicle. For a

Low tirepressurewarning lightPossiblecauseCustomer action requiredFlashingwarning lightSpare tire inuseRepair the damaged road wheel/tireand reinstall

Safety belt: Reminds you to fastenyour front driver and passengersafety belt. A Belt-Minder威 chimewill also sound to remind you tofasten your safety b

TPMS reset procedureThe TPMS reset procedure needs to be performed after each tirerotation.WARNING: To determine the required pressure for your vehicl

3. Cycle the ignition to the onposition with the engine off.4. Turn the hazard flashers on thenoff three times. This must beaccomplished within 10 sec

9. Remove the valve cap from the valve stem on the left rear tire;decrease the air pressure until the horn sounds.Training is complete after the horn

VEHICLE LOADINGThis section will guide you in the proper loading of your vehicle to keepyour loaded vehicle weight within its design rating capability

Example only:Cargo Weight – includes all weight added to the Base Curb Weight,including cargo and optional equipment.GAW (Gross Axle Weight) – is the

GAWR (Gross Axle Weight Rating) – is the maximum allowableweight that can be carried by a single axle (front or rear). Thesenumbers are shown on the S

• Example only:WARNING: Exceeding the Safety Compliance Certification Labelvehicle weight rating limits could result in substandard vehiclehandling or

WARNING: Do not use replacement tires with lower loadcarrying capacities than the original tires because they maylower the vehicle’s GVWR and GAWR lim

• A final example for your vehicle with 1400 lb. (635 kg) of cargo andluggage capacity. You and one of your friends decide to pick upcement from the l

TRAILER TOWINGWARNING: Never tow a trailer with this vehicle. Your vehicle isnot equipped to tow. No towing packages are available throughan authorize

Low tire pressure warning:Illuminates when your tire pressureis low. If the light remains on atstart up or while driving, the tirepressure should be c

STARTINGElectric vehiclesFor specific information on the Transit Connect Electric, refer to theAzure Dynamics TC-E Owner’s Guide Supplement.Positions

WARNING: Do not park, idle, or drive your vehicle in dry grassor other dry ground cover. The emission system heats up theengine compartment and exhaus

• Make sure the gearshift is in P(Park).3. Turn the key to II (on) withoutturning the key to III (start).Some warning lights will briefly illuminate.

Note: If the engine does not start on the first try, turn the key to the O(off) position, wait 10 seconds and try Step 2 again. If the engine stillfai

Association (CSA). Use only an extension cord that can be usedoutdoors, in cold temperatures, and is clearly marked “Suitable for Usewith Outdoor Appl

Make sure system is unplugged and properly stowed before driving thevehicle. While not in use, make sure the protective cover seals theprongs of the e

Even when the ABS is disabled,normal braking is still effective. Ifyour BRAKE warning lampilluminates with the parking brakereleased, have your brake

WARNING: If the parking brake is fully released, but the brakewarning lamp remains illuminated, the brakes may not beworking properly. See your author

WARNING: If a failure has been detected within theAdvanceTrac威 with RSC威 system, the stability control light willilluminate steadily. If the stability

control. Engine traction control works to limit drive-wheel spin bymomentarily reducing engine power. Brake traction control works to limitwheel spin

Park lamps: Illuminates when thepark lamps are turned on.Front fog lamps (if equipped):Illuminates when the front fog lampsare turned on.Rear fog lamp

During an event that activates the Roll Stability Control™ (RSC威), thestability control light in the instrument cluster will flash.Certain adverse dri

PREPARING TO DRIVEWARNING: Utility vehicles have a significantly higher rolloverrate than other types of vehicles.WARNING: In a rollover crash, an unb

the van on a regular basis. These drivers will gain valuable experiencehandling the van. This experience will help make each trip safer.The van should

BRAKE-SHIFT INTERLOCKThis vehicle is equipped with a brake-shift interlock feature that preventsthe gearshift lever from being moved from P (Park) whe

WARNING: If the parking brake is fully released, but the brakewarning lamp remains illuminated, the brakes may not beworking properly. See your author

WARNING: Always set the parking brake fully and make surethe gearshift is latched in P (Park). Turn the ignition to the offposition and remove the key

2 (Second)This position allows for second gear only.• Provides engine braking.• Use to start-up on slippery roads.• To return to D (Overdrive), move t

WARNING: This system is not designed to prevent contact withsmall or moving objects. The system is designed to provide awarning to assist the driver i

REARVIEW CAMERA SYSTEM (IF EQUIPPED)The rearview camera is located onthe rear doors. The camera systemprovides a video image whichappears in the rear

WARNING: Objects that are close to either corner of thebumper or under the bumper, might not be seen on the screendue to the limited coverage of the c

GAUGESSpeedometer: Indicates thecurrent vehicle speed.Tachometer: Indicates the enginespeed in revolutions per minute.Driving with your tachometerpoin

Driving with blind spot mirrorsBefore a lane change, check themain mirror first, then check theblind spot mirror. If no vehicles arepresent in the bli

DRIVING THROUGH WATERIf driving through deep or standingwater is unavoidable, proceed veryslowly. Never drive through waterthat is higher than the bot

ROADSIDE ASSISTANCEVehicles sold in the U.S. : Getting roadside assistanceTo fully assist you should you have a vehicle concern, Ford MotorCompany off

U.S. Ford vehicle customers who require Roadside Assistance, call1-800-241-3673.If you need to arrange roadside assistance for yourself, Ford MotorCom

The fuel pump shut-off switch isaccessible from behind the glovebox. The button will be raised whenthe switch is activated.To reset the switch:1. Turn

Standard fuse amperage rating and colorCOLORFuseratingMinifusesStandardfusesMaxifusesCartridgemaxifusesFuse linkcartridge2A Grey Grey — — —3A Violet V

The fuses are coded as follows:Fuse/RelayLocationFuse AmpRatingProtected Circuits117 — Not used118 — Not used119 — Not used120 — Headlamps, Low beam i

Fuse/RelayLocationFuse AmpRatingProtected Circuits128 — Battery saver relay (modifiedvehicle)130 15A Hazard flashers131 5A Power mirrors132 10A Light

Fuse/RelayLocationFuse AmpRatingProtected Circuits156 7.5A Right parking lamp/tail lamps157 7.5A License plate lamps158 10A Light switch159 20A Rear h

Fuse/RelayLocationFuse AmpRatingProtected Circuits179 7.5A Instrument cluster, Passiveanti-theft system (PATS),Accelerator pedal sensor, TPMS,Rearview

Seating and Safety Restraints 85Seating 85Personal Safety System™ 95Safety belt system 99Airbags 108Child restraints 120Tires, Wheels and Loading 139T

Engine coolant temperaturegauge: Indicates engine coolanttemperature. At normal operatingtemperature, the needle will be inthe normal range. If it ent

The high-current fuses are coded as follows:Fuse/RelayLocationFuse AmpRatingProtected circuits1 7.5A* Heated windshield telltale2 40A** Right heated w

Fuse/RelayLocationFuse AmpRatingProtected circuits20 — A/C clutch relay21A — Right heated windshield relay,Modified vehicle — Rear fan relay21B — Star

Fuse/RelayLocationFuse AmpRatingProtected circuits33 — Fuel pump relay diode34 — Gear shifter diode35 30A* Start lock relay36 — Modified vehicle — Lef

If you have a dissimilar spare tire/wheel, then it is intended fortemporary use only. This means that if you need to use it, you shouldreplace it as s

• Use more than one dissimilar spare tire/wheel at a time• Use commercial car washing equipment• Use snow chains on the end of the vehicle with the di

1. Open the cap in the rear of thevehicle and insert the end of the lugwrench into the guide hole.2. Turn the handle counterclockwiseand lower the spa

Tire change procedureWARNING: When one of the front wheels is off the ground, thetransmission alone will not prevent the vehicle from moving orslippin

3. Loosen each wheel lug nutone-half turn counterclockwise butdo not remove them until the wheelis raised off the ground.4. Align the slot on top of t

8. Remove the jack and fully tightenthe lug nuts in the order shown.Refer to Wheel lug nut torquespecifications later in this chapterfor the proper lu

7. Repeat this tightness check procedure when servicing the spare tirepressure (every six months, per scheduled maintenance information),or at any tim

2. Trip odometer: Registers the distance of individual journeys. Pressthe Reset button (4) until the trip odometer resets.3. Odometer: Registers the m

JUMP STARTINGWARNING: The gases around the battery can explode ifexposed to flames, sparks, or lit cigarettes. An explosion couldresult in injury or v

Connecting the jumper cablesNote: In the illustration, the vehicle on the bottom is used to designatethe assisting (boosting) battery.1. Connect the p

Removing the jumper cablesRemove the jumper cables in the reverse order that they wereconnected.Note: In the illustration, the vehicle on the bottom i

WRECKER TOWINGIf you need to have your vehicle towed, contact a professional towingservice or, if you are a member of a roadside assistance program, y

Emergency towingIn case of a roadside emergency with a disabled vehicle (without accessto wheel dollies, car hauling trailer, or flatbed transport veh

GETTING THE SERVICES YOU NEEDWarranty repairs to your vehicle must be performed by an authorizeddealer. While any authorized dealer handling your vehi

In Canada:Mailing addressCustomer Relationship CentreFord Motor Company of Canada, LimitedP.O. Box 2000Oakville, Ontario L6J 5E4Telephone1-800-565-367

IN CALIFORNIA (U.S. ONLY)California Civil Code Section 1793.2(d) requires that, if a manufactureror its representative is unable to repair a motor veh

THE BETTER BUSINESS BUREAU (BBB) AUTO LINE PROGRAM(U.S. ONLY)Your satisfaction is important to Ford Motor Company and to your dealer.If a warranty con

UTILIZING THE MEDIATION/ARBITRATION PROGRAM(CANADA ONLY)For vehicles delivered to authorized Canadian dealers. In those caseswhere you continue to fee

2. Trip odometer: Registers the distance of individual journeys. Pressthe Reset button (5) until the trip odometer resets.3. Odometer: Registers the m

If your vehicle must be serviced while you are traveling or living inAsia-Pacific Region, Sub-Saharan Africa, U.S. Virgin Islands, CentralAmerica, the

If you buy your vehicle in North America and then relocate to any of theabove locations, register your vehicle identification number (VIN) andnew addr

REPORTING SAFETY DEFECTS (U.S. ONLY)If you believe that your vehicle hasa defect which could cause a crashor could cause injury or death, youshould im

WASHING THE EXTERIORWash your vehicle regularly with cool or lukewarm water and a neutralpH shampoo, such as Motorcraft威 Detail Wash (ZC-3-A), which i

WAXING• Wash the vehicle first.• Use a quality wax that does not contain abrasives.• Do not allow paint sealant to come in contact with any non-body(l

ENGINEEngines are more efficient when they are clean because grease and dirtbuildup keep the engine warmer than normal. When washing:• Take care when

PLASTIC (NON-PAINTED) EXTERIOR PARTSUse only approved products to clean plastic parts. These products areavailable from your authorized dealer.• For r

INSTRUMENT PANEL/INTERIOR TRIM AND CLUSTER LENSClean the instrument panel, interior trim areas and cluster lens with aclean, damp, white cotton cloth,

INTERIORFor fabric, carpets, cloth seats and safety belts:• Remove dust and loose dirt with a vacuum cleaner.• Remove light stains and soil with Motor

UNDERBODYFlush the complete underside of your vehicle frequently. Keep body anddoor drain holes free from packed dirt.Electric vehiclesFor specific in

AUDIO SYSTEMSAM/FM stereo (if equipped)WARNING: Driving while distracted can result in loss of vehiclecontrol, accident and injury. Ford strongly reco

SERVICE RECOMMENDATIONSTo help you service your vehicle, we provide scheduled maintenanceinformation which makes tracking routine service easy.If your

OPENING THE HOOD1. Lift and swivel the hood badgeback.2. Insert the key and turn it to theleft to release the primary latch.Then, turn they key to the

IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT1. Engine coolant reservoir2. Engine oil filler cap3. Brake fluid reservoir4. Battery5. Power distribu

WINDSHIELD WASHER FLUIDAdd fluid to fill the reservoir if thelevel is low. In very cold weather, donot fill the reservoir completely.Only use a washer

To prolong the life of the wiper blades, it is highly recommended toscrape off the ice on the windshield before turning on the wipers. Thelayer of ice

Adding engine oil1. Check the engine oil. For instructions, refer to Checking the engineoil in this chapter.2. If the engine oil level is not within t

Do not use supplemental engine oil additives, cleaners or other enginetreatments. They are unnecessary and could lead to engine damage thatis not cove

WARNING: Batteries normally produce explosive gases whichcan cause personal injury. Therefore, do not allow flames, sparksor lighted substances to com

• If you do not allow the engine to relearn its idle trim, the idlequality of your vehicle may be adversely affected until the idletrim is eventually

When the engine is cold, check thelevel of the engine coolant in thereservoir.• The engine coolant should be at the MAX level as listed on the enginec

(1–4): (Memory Presets): When tuned to any station, press and hold apreset button until sound returns.MENU: Press once to access MAN (Manual tuning).

• DO NOT MIX different colors or types of coolant in your vehicle.Make sure the correct coolant is used. Mixing of engine coolants mayharm your engine

3. Step back while the pressure releases.4. When you are sure that all the pressure has been released, use thecloth to turn it counterclockwise and re

Severe climatesIf you drive in extremely cold climates:• It may be necessary to increase the coolant concentrationabove 50%.• NEVER increase the coola

How fail-safe cooling worksIf the engine reaches a preset over-temperature condition, the enginewill automatically switch to alternating cylinder oper

WHAT YOU SHOULD KNOW ABOUT AUTOMOTIVE FUELSImportant safety precautionsWARNING: Do not overfill the fuel tank. The pressure in anoverfilled tank may c

• Avoid getting fuel liquid in your eyes. If fuel is splashed in the eyes,remove contact lenses (if worn), flush with water for 15 minutes andseek med

Use the following guidelines to avoid electrostatic charge build-up whenfilling an ungrounded fuel container:• Place approved fuel container on the gr

WARNING: The fuel system may be under pressure. If the fuelfiller cap is venting vapor or if you hear a hissing sound, waituntil it stops before compl

Fuel qualityIf you are experiencing starting, rough idle or hesitation driveabilityproblems during a cold start, try a different brand of “Regular” un

ESSENTIALS OF GOOD FUEL ECONOMYMeasuring techniquesYour best source of information about actual fuel economy is you, thedriver. You must gather inform

Accessory delay: Your vehicle is equipped with accessory delay. Withthis feature, the window switches and radio may be used for up to10 minutes after

Calculating fuel economy1. Fill the fuel tank completely and record the initial odometer reading(in miles or kilometers).2. Each time you fill the tan

• You may want to turn off the speed control in hilly terrain ifunnecessary shifting between the top gears occurs. Unnecessaryshifting of this type co

EMISSION CONTROL SYSTEMWARNING: Do not park, idle, or drive your vehicle in dry grassor other dry ground cover. The emission system heats up theengine

Do not make any unauthorized changes to your vehicle or engine. Bylaw, vehicle owners and anyone who manufactures, repairs, services,sells, leases, tr

Readiness for Inspection/Maintenance (I/M) testingSome state/provincial and local governments may haveInspection/Maintenance (I/M) programs to inspect

POWER STEERING FLUIDCheck the fluid. Refer to scheduledmaintenance information.1. Start the engine and let it rununtil it reaches normal operatingtemp

TRANSMISSION FLUIDElectric vehiclesFor specific information on the Transit Connect Electric, refer to theAzure Dynamics TC-E Owner’s Guide Supplement.

Low fluid levelDo not drive the vehicle if the fluidlevel is at the bottom of thedipstick. If the fluid level is belowthe MIN mark, add fluid in 1/2 p

If an overfill occurs, excess fluidshould be removed by an authorizeddealer. If the fluid level is above theMAX mark, fluid will have to beremoved.An

Note: Failure to use the correct air filter element may result in severeengine damage. The customer warranty may be void for any damage tothe engine i

6. ON/OFF/Volume: Press VOL -PUSH to turn ON/OFF. Turn VOL -PUSH to increase/decrease volume.7. CLK (Clock): Press CLK totoggle between the clock and

Fuel system• Fill the fuel tank with high-quality fuel until the first automatic shutoffof the fuel pump nozzle.Note: During extended periods of vehic

MOTORCRAFT PART NUMBERSComponent 2.0L I4 engineEngine air filter element FA-1900Oil filter FL-910S1Battery BXT-96R-590Spark plugs2Cabin air filter FP3

MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIESItem CapacityFord Part Name orEquivalentFord Part Number / FordSpecificationBrake fluidBetween MINand

Item CapacityFord Part Name orEquivalentFord Part Number / FordSpecificationEngine coolant 6.1 quarts (5.7L)Motorcraft威 SpecialtyOrange Engine Coolant

ENGINE DATAEngine 2.0L I4 engineCubic inches 121Required fuel Minimum 87 octaneFiring order 1–3–4–2Ignition system C.O.PCompression ratio 10.0:1Spark

Engine drivebelt routingIDENTIFYING YOUR VEHICLESafety Compliance Certification LabelThe National Highway Traffic SafetyAdministration Regulations req

Vehicle identification number (VIN)The vehicle identification number islocated on the driver sideinstrument panel.Please note that in the graphic,XXXX

TRANSMISSION CODE DESIGNATIONSYou can find a transmission code onthe Safety Compliance CertificationLabel. The following table tells youwhich transmis

FORD CUSTOM ACCESSORIES FOR YOUR VEHICLEA wide selection of Ford Custom Accessories are available for yourvehicle through your local Ford or Ford of C

Peace of mind•Remote start •Back up alarm*•Keyless entry keypad •Protective seat covers*•Bumper mounted parking sensors**Ford Licensed Accessories (FL

WARNING: Driving while distracted can result in loss of vehiclecontrol, accident and injury. Ford strongly recommends thatdrivers use extreme caution

FORD ESP EXTENDED SERVICE PLANS (U.S. ONLY)More than 32 million Ford and Lincoln owners have discovered thepowerful protection of Ford ESP. It is the

Plus, exclusive 24/7 roadside assistance, including:• Towing, flat-tire change and battery jump starts.• Out-of-fuel and lock-out assistance.• Travel

Ford Extended Service Plan2722012 Transit Connect (tst)Owners Guide, 1st PrintingUSA (fus)PAGE POSITION: 272 JOB: @zeta.tweddle.com/ford_pdm/ford/own2

FORD ESP EXTENDED SERVICE PLANS (CANADA ONLY)You can get more protection for your vehicle by purchasing a FordExtended Service Plan (ESP). Ford ESP is

GENERAL MAINTENANCE INFORMATIONElectric vehiclesFor specific information on the Transit Connect Electric, refer to theAzure Dynamics TC-E Owner’s Guid

Ford strongly recommends the use of genuine Ford replacement parts.Parts other than Ford, Motorcraft威 or Ford-authorized remanufacturedparts that are

Genuine Ford and Motorcraft姞 replacement partsDealerships stock Ford and Motorcraft威 branded replacement parts.These parts meet or exceed Ford Motor C

Check every six monthsBattery connections; clean if necessaryBody and door drain holes for obstructions; clean if necessaryCooling system fluid level

what’s been checked, what’s okay, as well as those things that mayrequire future or immediate attention. The multi-point vehicle inspectionis one more

NORMAL SCHEDULED MAINTENANCE AND LOGThe following section contains the “Normal Schedule”. This schedule ispresented at specific mileage (kilometer) in

CD playerTo load a CD, simply insert the disc, label side up, into the CD slot.(Eject): Press to eject the CD.(Seek): Press to access the previous/nex

Miles (x 1,000)* 7.5 15 22.5 30 37.5 45 52.5 60 67.5 75Kilometers (x 1,000)* 12 24 36 48 60 72 84 96 108 120Months* 6 12 18 24 30 36 42 48 54 60Change

Miles (x 1,000)* 82.5 90 97.5 105 112.5 120 127.5 135 142.5 150Kilometers (x 1,000)* 132 144 156 168 180 192 204 216 228 240Months* 66 72 78 84 90 96

Every 15,000 miles(24,000 km)Replace cabin air filter (if equipped)Every 30,000 miles(48,000 km)Replace climate-controlled seat filter (ifequipped)Rep

Maintenance schedule logDEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDAT

DEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HO

DEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HO

SPECIAL OPERATING CONDITIONSIf you operate your vehicle primarily in one of the more demandingconditions listed below, you will need to have some item

Extensive idling and/or low-speed driving for long distances asin heavy commercial use (i.e. delivery, taxi, patrol car or livery)Inspect frequently,s

Operating in dusty conditions such as unpaved or dusty roadsInspect frequently,service as requiredReplace cabin air filter (if equipped)Replace engine

Off-road operationInspect frequently,service as requiredInspect steering linkage, ball joints and U-joints;lubricate if equipped with grease fittingsR

• VEHICLE ID: Press to view the vehicle’s VIN number.• BT ON/OFF: Press to turn Bluetooth ON/OFF (if equipped). Refer toBluetooth hands free system la

Special operating condition logDEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER

DEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HOURS:DAT E:MILEAGE:DEALER VALIDATION:P&A CODE:RO#: HO

EXCEPTIONSThere are several exceptions to the Normal Schedule. They are listed below:Normal vehicle axle maintenance: Rear axles and power take-off(PT

Edge/MKX AWD only – vehicles operating off-road in sand during highambient temperatures must replace the AWD PTU (All-wheel drivePower Transfer Unit)

AAdvanceTrac ...177Airbag supplemental restraintsystem ...108, 117and child safety seats ...

instrument panel ...227interior ...228plastic parts ...226safety belts ...

Four-Wheel Drive vehiclespreparing to drive yourvehicle ...181Fuel ...244ca

interior lamps ...55, 57replacing bulbs ...58LATCH anchors ...128Liftgate ...

Safety restraints ...99–101, 103Belt-Minder威 ...104extension assembly ...103for adults ...

VVehicle Identification Number(VIN) ...266Vehicle loading ...163Ventilating your vehicle

Cleaning 223Maintenance and Specifications 230Engine compartment 232Engine oil 234Battery 236Engine coolant 238Fuel information 244Air filter(s) 258Pa

2. (Phone): Press to mute theplaying media. Press again to returnto the playing media.3. MENU: Press MENU repeatedlyto access to the following setting

• Track/Folder mode: Available only on MP3 discs in CD mode. InTrack mode, pressingSEEK, SEEK will scroll through alltracks on the discIn Folder mode,

7. SHUFFLE: In CD/MP3 mode,press SHUFFLE to engage shufflemode. SHUFFLE ON will appear inthe display. If you wish to engage shuffle mode right away, p

14. AM/FM: Press AM/FM to selectAM/FM1/FM2 frequency band.15. ON/OFF/Volume: PressVOL-PUSH to turn on/off. TurnVOL-PUSH to increase/decreasevolume.Not

The auxiliary input jack allows youto connect your portable musicplayer and play music through thevehicle speakers with high fidelity.Required equipme

Troubleshooting:1. Do not connect the audio input jack to a line level output. Line leveloutputs are intended for connection to a home stereo and are

Your vehicle may be equipped with aUSB port located just beneath theaudio system. This feature allowsyou to plug in media playingdevices, memory stick

PHONE COMPATIBILITYWhile your Bluetooth system supports a variety of features, many aredependent upon the functionality of your cellular phone with Bl

To pair/bond subsequent phones to the system, simply follow theprevious procedure.Phonebook entries: Once the Bluetooth system connects to yourphone,

MicrophoneYour vehicle has a microphonelocated in the A-pillar for thehands-free phone features and voicecommands.To mute the microphone: Duringan act

CONGRATULATIONSCongratulations on acquiring your new Ford. Please take the time to getwell acquainted with your vehicle by reading this handbook. The

CD player voice commandsPress the VOICE button on thestalk. After the tone, say, “CDplayer” and then any of thefollowing commands:• Play • Track1• Shu

Play directory: Allows you to let the system tell you of all the storedradio stations.Note: Using the system with the engine off will drain the batter

• or Home or H•or Office or O•or Fax or FMaking a call using voice commandsTo make a hands-free call using your system:1. Press the VOICE button on th

Answering a second incoming callIf another calls comes in while you are already on an active call, you willhear a beep. You have the choice to end you

Deleting a phoneA paired (bonded) phone can be deleted from the system at any time aslong as the phone is not involved in an active call. To delete a

CD/CD player careDo:• Handle discs by their edges only.(Never touch the playingsurface).• Inspect discs before playing.• Clean only with an approved C

CDs with homemade paper(adhesive) labels should not beinserted into the CD player asthe label may peel and cause theCD to become jammed. It isrecommen

MANUAL HEATING AND AIR CONDITIONING SYSTEM1. Temperature control: Controls the temperature of the airflow in thevehicle. For optimum defrosting perfor

4. Recirculated air: Press to activate/deactivate air recirculationin the vehicle cabin. Recirculated air may reduce the amount of timerequired to coo

To aid in side window defogging/demisting in cold weather:1. Select.2. Select A/C.3. Adjust the temperature control to maintain comfort.4. Set the fan

Warning symbols on your vehicleWhen you see this symbol, it isimperative that you consult therelevant section of this guide beforetouching or attempti

REAR WINDOW DEFROSTER (IF EQUIPPED) / HEATED MIRRORS(IF EQUIPPED)The rear defroster control is locatedon the instrument panel above theradio and works

HEADLAMP CONTROLTurns the lamps off.Turns on the parking lamps,instrument panel lamps, licenseplate lamps and tail lamps.Turns the headlamps on.Front

Pull the headlamp control towards you until the second detent is felt toturn the rear fog lamp on. The rear fog lamp indicator lightwillilluminate.Not

WARNING: Always remember to turn on your headlamps atdusk or during inclement weather. The Daytime Running Lamp(DRL) system does not activate the tail

On the wall or screen you willobserve a flat zone of high intensitylight located at the top of the righthand portion of the beam pattern. Ifthe top ed

INTERIOR LAMPSDome lampThe dome lamp is equipped with acontrol switch that will illuminatewhen:• the doors are closed and theswitch is in the right po

Examples of acceptable condensation are:• Presence of thin mist (no streaks, drip marks or droplets)• Fine mist covers less than 50% of the lensExampl

Replacing interior bulbsCheck the operation of all bulbs frequently.Replacing front dome lamps1. Make sure the headlamp switch isin the off position.2

Replacing reading bulbs1. Open the reading lamp assembly.2. Pull the bulb straight out andreplace it.3. After the bulb has been replaced,close the lam

Replacing front parking lamp bulbs1. Make sure the headlamp controlis in the off position.2. Turn the cover counterclockwiseand remove it.3. Remove th

Do not add friction modifier compounds or special break-in oils sincethese additives may prevent piston ring seating. See Engine oil in theMaintenance

3. Pull the bulb straight out of thesocket.Install in reverse order.Replacing front fog lamp bulbs (if equipped)1. Make sure the headlamp switch isin

3. Remove the bulb socket from thelamp assembly by turning itcounterclockwise.4. Pull the bulb straight out of thesocket.Install in reverse order.Ligh

Replacing front and rear side marker bulbs1. Make sure the headlamp controlis in the off position and then openthe cargo door.2. Remove the side marke

Replacing high-mount brake lamp bulbsSee your authorized dealer for replacement.Replacing license plate lamp bulbs1. Make sure the headlamp controlis

WINDSHIELD WIPERSMove the lever down for a singlewipe.For intermittent operation,move control up one position andadjust the rotary control to thedesir

TILT AND TELESCOPE STEERING COLUMNRelease the locking lever to adjustthe height of the steering wheel andits distance from the driver.Return the lever

CENTER CONSOLEYour vehicle has a variety of console features. These include:• Cupholders• Storage area• Power window switches (if equipped)WARNING: Us

To prevent the fuse from being blown, do not use the power point(s)over the vehicle capacity of 12V DC/135W. If the power point or cigarlighter socket

INTERIOR MIRRORThe interior rearview mirror has two pivot points on the support armwhich lets you adjust the mirror up or down and from side to side.W

EXTERIOR MIRRORSPower side view mirrors (if equipped)WARNING: Do not adjust the mirror while the vehicle is inmotion.To adjust your mirrors:1. Rotate

Using your vehicle as an ambulanceDo not use this vehicle as an ambulance.Your vehicle is not equipped with the Ford Ambulance PreparationPackage.DATA

Using speed controlThe speed controls are located on the steering wheel. The followingbuttons work with speed control:ON: Press to turn speed controlo

Increasing speed while using speed controlTo set a higher speed:• Press and hold SET + until you get to the desired speed, then release.You can also u

SeekMove the SEEK switch up or down:• In radio mode, this will locate thenext radio station up or down thefrequency band.• In CD mode, it will select

SYNC威 hands-free control feature (if equipped)Voice: Press the top button toactivate or deactivate voice control.Move the SEEK switch up to answera ca

DUAL REAR DOORSOpen the right hand door first fromeither the outside (1) or inside (2)the vehicle.Open the left hand door second bysqueezing the handl

Opening the doors fullyPush the yellow button located onthe door and swing it open. Thecheck arms will automaticallyre-engage when the doors areclosed

KEYSThe key operates all locks on your vehicle. You should always carry asecond key with you in a safe place in case you require it in anemergency.If

OPENING THE SLIDING DOORNote: the right-hand sliding door is inhibited from opening fullywhen the fuel filler flap is unlocked and open.REMOTE ENTRY S

The typical operating range for your remote entry transmitter isapproximately 33 feet (10 meters). A decrease in operating range couldbe caused by:• w

Switching from two-step to one-step door unlockingYour vehicle comes with two-step unlocking enabled. With the vehiclelocked, unlocking can be switche

Note: EDR data is recorded by your vehicle only if a non-trivialcrash situation occurs; no data is recorded by the EDR undernormal driving conditions

2. Open the transmitter unit byseparating the retaining clips on thesides with the flat object.3. Remove the old battery.Note: Please refer to localre

How to reprogram your remote entry transmittersYou must have all remote entry transmitters (maximum of four)available before beginning this procedure.

The inside lights will not turn off if:• they have been turned on with the dome lamp control, or• any door is open.SECURILOCK姞 PASSIVE ANTI-THEFT SYST

If a problem occurs with the SecuriLock威 system, the indicator will flashrapidly or glow steadily when the ignition is in the on position. If thisoccu

• If two previously programmed coded keys are not available, you musttake your vehicle to your authorized dealer to have the spare key(s)programmed.1.

FRONT SEATSWARNING: Reclining the seatback can cause an occupant toslide under the seat’s safety belt, resulting in severe personalinjuries in the eve

The adjustable head restraintsconsist of:• a trimmed energy absorbing foamand structure (1),• two steel stems (2),• a guide sleeve adjust/releasebutto

WARNING: The adjustable head restraint is a safety device.Whenever possible it should be installed and properly adjustedwhen the seat is occupied.To r

Properly adjust the head restraint so that the top of the head restraint iseven with the top of your head and positioned as close as possible to theba

Move the front control to raise orlower the seat cushion.Using the manual lumbar supportThe lumbar support control islocated on the in-board side of t

Additionally, when you connect to Traffic, Directions andInformation (if equipped, U.S. only) the service uses GPStechnology and advanced vehicle sens

REAR SEATSSecond row adjustable head restraints (if equipped)Your vehicle may be equipped with head restraints that are verticallyadjustable.WARNING:

3. Lower the head restraint bypressing and holding the guidesleeve adjust/release button andpushing down on the head restraint.Properly adjust the hea

2. Simultaneously press and holdboth the adjust/release button andthe unlock/remove button, then pullup on the head restraint.To reinstall the adjusta

Folding down the rear seat (if equipped)One or both rear seatbacks can be folded down to provide additionalcargo space.To lower a single seatback:1. R

When raising the seatback(s), makesure the lever is locked and youhear the seat latch into place.Returning the seat to the upright positionWARNING: Be

• Locked• UnlockedPERSONAL SAFETY SYSTEM™The Personal Safety System provides an improved overall level of frontalcrash protection to front seat occupa

• The electrical wiring for the airbags, crash sensor(s), safety beltpretensioners, front safety belt usage sensors, driver seat positionsensor, and i

Front passenger sensing systemFor airbags to do their job they must inflate with great force, and thisforce can pose a potentially deadly risk to occu

Front outboard safety belt pretensionersThe safety belt pretensioners at the front outboard seating positionsactivate with the front airbags during fr

SAFETY BELT SYSTEMWARNING: Always drive and ride with your seatback uprightand the lap belt snug and low across the hips.WARNING: To reduce the risk o